Valorization of Citrus Reticulata Peels for Flavonoids and Antioxidant Enhancement by Solid-State Fermentation Using Aspergillus niger CGMCC 3.6189

The bioactive components and bioactivities of citrus peel can be enhanced with microbial fermentation. Accordingly, this study investigated the ability of Aspergillus niger CGMCC3.6189 to accumulate flavonoids in Citrus reticulata peel powder (CRPP) by solid-state fermentation (SSF). Under the optimal SSF conditions including 80% moisture, 30 °C, pH 4.0, 4 × 107 spores/g d.w. CRPP, and 192 h, the total phenolic content (TPC), total flavonoid content (TFC), and 2,2'-azinobis-(3-ethylbenzothiazoline-6-sulfonic acid) (ABTS) and 1,1-diphenyl-2-picrylhydrazyl radical (DPPH) scavenging activities of fermented CRPP significantly increased by 70.0, 26.8, 64.9, and 71.6%, respectively. HPLC analysis showed that after fermentation, the contents of hesperidin, nobiletin, and tangeretin were significantly increased from 19.36, 6.31, and 2.91 mg/g to 28.23, 7.78, and 3.49 mg/g, respectively, while the contents of ferulic acid and narirutin were decreased under the optimal fermentation conditions. Fermentation time is one of the most important factors that affect the accumulation of flavonoids and antioxidant activity; however, extended fermentation time increased the darkness of CRPP color. Therefore, our study provides a feasible and effective SSF method to increase the bioactive components and the antioxidant activity of CRPP that may be used in food, nutraceutical, and medicinal industries.

Ultrasonic-assisted extraction of bioactive chlorogenic acid from heilong48 soybean variety: Parametric optimization and evaluation of physicochemical and bioactive properties.

Chlorogenic acid (CA), especially that found in soybeans, is a rich bioactive compound but has received very little attention in research settings in past decades. Ultrasonic-assisted extraction (UAE) could be an efficient method to increase CA release from soybeans. Hence, this study aimed to optimize UAE parameters for CA extraction from heilong48 soybean (HS) variety and evaluate the physicochemical and bioactive properties of the soybean. Optimization of ultrasound parameters with a Box-Behnken design found a frequency of 20.0 kHz, a power density of 30.0 W/L), a temperature of 37.9°C, and a time of 28.0 min to be the best conditions, which gave a CA yield of 5.007 ± 0.033 mg/g and 2,2-diphenyl-1-picrylhydrazyl (DPPH) radical scavenging activity of 93.197 ± 0.213 µmol of AA eq/g dry sample; these were higher than those of a non-ultrasound-treated (raw) HS sample (CA yield of 1.627 ± 0.528 mg/g and DPPH radical scavenging activity of 10.760 ± 0.207 µmol of AA eq/g dry sample). A satisfactory model was obtained. Scanning electron microscopy results confirmed the structural changes of the HS variety caused by the optimized UAE parameters. High total polyphenol contents (TPCs; 4.726 ± 0.002 mg GAE/g) and total phenolic acids (1.883 ± 0.005 mg GAE/g) and low total flavonoid contents (0.040 ± 0.008 mg RE/g) were obtained. A positive linear correlation between antioxidant activity and TPC was established. A protein-phenolic interaction in the HS variety was observed. The results established that polyphenols should be considered a significant component of the HS variety. Likewise, the HS variety could be used for CA extraction.

Single-frequency ultrasonic extraction of bioactive chlorogenic acid from heilong48 soybean variety: Parametric optimization and comprehensive evaluation of physicochemical and bioactive properties.

Chlorogenic acid (CA), especially that found in soybean, is a rich bioactive compound but has received very little attention in research settings in past decades. Ultrasonic-assisted extraction (UAE) could be an efficient method to increase CA release from soybean. Hence, this study aimed to optimize UAE parameters for CA extraction from heilong48 soybean (HS) variety with comprehensive physicochemical and bioactive properties evaluation. Optimization of ultrasound parameters with Box-Behnken design (BBD) found frequency (20.0 kHz), power density (30.0 W/L), temperature (37.9℃), and time (28.0 min) as the significant optimized parameters, which gave CA yield of 5.007 ± 0.033 mg/g and DPPH of 93.197 ± 0.213 µmol AA eq/g dry sample and were higher than that of nonultrasound-treated (raw) HS sample (CA yield, 1.627 ± 0.528 mg/g, and DPPH, 10.760 ± 0.207 µmol AA eq/g dry sample). A satisfactory model was obtained. SEM results confirmed the structural alterations of HS variety caused by the optimized UAE parameters. High TPC (4.726 ± 0.002 mg GAE/g), TPA (1.883 ± 0.005 mg GAE/g), and low TFC (0.040 ± 0.008 mg RE/g) were obtained. A positive linear correlation between antioxidant activity and TPC was established. Protein-phenolic interaction in HS variety was observed. The results proposed that polyphenols should be considered as a significant component of HS variety. Likewise, HS variety could be utilized for CA extraction.

Highly stable, antihypertensive, and antioxidative peptide production from Apostichopus japonicus by integrated enzymatic membrane reactor and nanofilter-purification mechanism.

Enzymatic hydrolysis-offline and membrane separation (EH-offline MS), enzymatic membrane reactor (EMR) (various operational modes), and conjoined nanofilter-purification (desalination) were used to produce highly stable antihypertensive and antioxidative peptides from ultrasonic-slurry viscosity reduced sea cucumber (A. japonicus) protein. The adoption of the optimum batch parameters by EMR-gradient diafiltration feeding (GDF), water feeding, and substrate feeding ensured a significant (p < 0.05) enhancement in protein conversion degree (PCD) by 60.39, 46.69, and 23.33%, respectively, over the conventional EH-offline MS. Also, the antihypertensive activity (ACE-inhibitory potency) of the peptides produced was in the order EMR-GDF > substrate feeding > water feeding > batch process > EH-offline MS. The EMR-GDF and nanofilter-purification produced highly digestible peptides with ACE-inhibition activities of 79.44% and 77.57% for gastric and gastrointestinal digests, respectively. Peptides with molecular weights of 1000-500 Da and 500 Da significantly contributed to the antihypertensive potency of desalinated peptides. In vitro simulated peptides showed a significant increase in the hydroxyl radical scavenging activity for gastric (77.27%) and gastrointestinal (85.32%) digests. The antioxidative stability of the produced peptides was least affected by high-temperature storage. The high arginine (Arg) and hydrophobic amino acid (HAA) content of the peptides resulted in their improved digestibility. Therefore, conjoined EMR-GDF and nanofilter-purification in the production of highly stable desalinated bioactive peptides for industrial applications could be a viable alternative.

Tracking the dynamic changes of a flavor, phenolic profile, and antioxidant properties of Lactiplantibacillus plantarum- and Saccharomyces cerevisiae-fermented mulberry wine.

The process of fermentation renders the superior quality of mulberry wine based on the microorganisms utilized. The present study aimed at investigating the changes and correlation between phenols and product quality of mulberry wine fermented with Lactiplantibacillus plantarum and Saccharomyces cerevisiae combinatorially. Total anthocyanins concentration (TAC), polyphenols concentration (TPC), flavonoids concentration (TFC), and antioxidant capacity decreased significantly with high correlation in the fermentation process. TAC gradually reduced with a loss rate of 47.98% from 0 to third day of fermentation. Fermented mulberry wine obtained indicated a dynamic balance due to the presence of p-hydroxybenzoic acids as compared to the primary phenolic constituent. Chlorogenic acid usually presents in mulberry juice. The relative intensity of sourness was the most prominent and reached the maximum (10.93) on day 2 of fermentation. A total of 21 volatile esters were quantified (6621.59 µg/L), which contributed significantly to the aroma of mulberry wine. The enhanced quality of fermented mulberry wine showed contraindications with decreased constituents and escalated wine quality. Rather than usual single inoculum, fermentation combination of LAB and yeast holistically influenced the color, taste, fragrance, phenolic profiles, and antioxidant properties in mulberry wine, ensuring palatability and fit for commercialization prospects.